莆田水箱保冷b1級橡塑保溫管 隔熱橡塑海綿管價格行情

橡塑保溫材料與其他保溫材料的泡孔結構比：

Rubber and plastic heat preservation material and other insulation foam pore structure than:

1、玻璃纖維：開孔結構水汽滲透率*（濕阻因子為3-5），導致隨使用時間延長導熱系數升高，使保溫效果大大降低。

1, glass fibre: open pore structure high water vapor permeability (wet resistance factor for 3 to 5), result in higher with the extension of use time coefficient of thermal conductivity, the heat preservation effect is reduced greatly.

2、發泡聚乙烯：連孔結構，添加阻燃劑后有較高的水汽滲透率（濕阻因子為1000），其材質硬而發脆，易破損，壽命短。

2, foaming polyethylene: even the pore structure, adding flame retardant has a high water vapor permeability (wet resistance factor of 1000), the material of hard and brittle, easy damage, short service life.

3、橡塑保溫材料：閉孔結構有極小的水汽滲透率（濕阻因子為10000以上）能長期保持較低的導熱系數。

3, rubber and plastic heat preservation material: obturator structure with minimal water vapor permeability (wet resistance factor of 10000 or above) to maintain low coefficient of thermal conductivity for a long time.

采暖、空調管道保溫材料性能比較表

Heating, air conditioning pipe heat preservation material performance comparison table

材料名稱 密度 導熱系數 溫度 經濟指標

The name of the material Density coefficient of thermal conductivity temperature indicators

水泥珍珠巖管 250-400 0.058-0.087 <600 不適用

Cement perlite tube 250-400-0.058-0.087 < 600 shall not apply

巖棉保溫管 100-200 0.082-0.058 -268-350 綜合成本高

Rock wool insulating tubes, 100-200-0.082-0.058-268-350 comprehensive cost is high

硅酸鋁纖維管 300-380 0.047-0.058 ≤1000 價格較高

Aluminum silicate fiber, 300-380-0.047-0.058 or less 1000 price is higher

聚苯乙烯塑料管20-50 0.031-0.047 -80-70 價格適中

Polystyrene plastic pipe 20 to 50 moderate price 0.031-0.047-80-80

聚氨酯預制保溫管 30-42 0.023 50-160 成本高

Prefabricated polyurethane insulation pipe 30-50-160 0.023 42 cost is high

橡塑絕熱保溫管 50-60 0.032 -50-110 價格相對低廉

Rubber insulation pipe 50 to 60 0.032-50-110 price is relatively cheap

水泥珍珠巖，巖棉，聚苯乙烯塑料

Cement perlite, rock wool, polystyrene plastics

莆田水箱保冷b1級橡塑保溫管 隔熱橡塑海綿管價格行情

橡塑保溫管生產廠家在產品的運輸過程中總會遇到這樣那樣的問題，那能否對這些問題進行正確的分析，并提出解決方案就顯得尤為重要了。下面小編就來給您科普一下。

Rubber insulation pipe manufacturers in the process of the transportation of products will always meet this or that kind of problem, is that the correct analysis of these problems, and puts forward solution is particularly important. Below small make up just to give you the popular science.

    橡塑保溫管能夠減少取暖能源消耗，是新一代的節能保溫材料。上世紀70年代，不少國家已經開始重視建筑節能，橡塑保溫管開始走向市場，有效的減少了取暖保溫消耗的能源。

Rubber insulation pipe can reduce heating energy consumption, is the new generation of energy-saving insulation materials. In the 1970 s, many countries have begun to attach importance to building energy efficiency, rubber insulation pipe began to market, reduce the heating heat consumption of energy.

七、橡塑保溫材料前景

Seven, rubber and plastic heat preservation material prospects

7.1、保溫建材行業覆蓋面比較廣，主要分為室外墻體保溫和室內管道保溫，室內空調保溫中的橡塑保溫材料僅僅是其中一個細分材料，主要是應用與中央空調通風管道，冷凝水管道采用，屬于工程項目上的機電安裝分包中的一項輔材。但是針對整個保溫建材行業，整體的趨勢，市場容量還是在不斷擴大的，因?yàn)閦ui基本的有兩個方面，一個是跟房地產進行掛鉤，一個是根據國家要求掛鉤。

7.1, heat preservation building materials industry coverage more widely, mainly divided into outdoor wall heat preservation and the indoor pipeline insulation, indoor air conditioning heat preservation of rubber and plastic heat preservation material is just one of the subdivision, is mainly used with the central air conditioning ventilation pipes, condensate pipes adopts, belongs to the electromechanical installation works on the project of an auxiliary material. But for the entire thermal insulation building materials industry, the overall trend, the market capacity is also growing, as the most basic two aspects, one is linked with real estate, one is according to the national requirements.

   7.2 、 保溫建材行業歸為國家要求的節能行業，國家在2007年出臺了GB50411-2007《建筑節能工程施工質量驗收規范》，其中就對建筑節能施工質量進行明確規定。所有建筑設置在驗收并且各地目前都是采取工程竣工驗收中建筑節能必須先行驗收，也就是說建筑節能必須*驗收，驗收合格后才允許后面的分部工程驗收。目前，節能驗收必須有當?shù)毓こ藤|(zhì)量監督部門到場驗收，而且必須出具圍護結構傳熱系數現場檢測報告。各地監督部門為當?shù)刈》亢统青l(xiāng)建設部，也稱建委，設立的節能辦公室監督完成。如果是住宅工程，還必須進行工程節能系數的設計值在制定位置進行公示。

7.2, heat preservation building materials industry as the requirements of the national energy saving industry, national in 2007 issued GB50411-2007 "construction quality acceptance of building energy conservation engineering, including rules on building energy-saving construction quality. All buildings set in acceptance around at present is to project completion and acceptance of building energy conservation must come first acceptance, that is to say, building energy efficiency must be the first acceptance, acceptance before allowing the back of the division of the acceptance of work. At present, the energy conservation acceptance must be present with local engineering quality supervision department acceptance, and must be issued by heat transfer coefficient of enclosure structure field test report. Around the supervision department for the local housing and urban-rural development, also known as build appoint, set up a complete energy saving office of supervision. If it is a residential project, also must carry on the design of the energy-saving coefficient value in setting position of the public.

   7.3 、 建材類行業受房地產的影響較大，例如2014、2015房地產發展勢頭放緩以后，建材行業增速也在下降。所以保溫建材行業依托房地產行業較為緊密，增速會受影響。同時在舊房改造項目上也會涉及到保溫建材。

7.3 class is strongly influenced by the real estate industry, building materials, such as 2014, 2015, after the real estate development momentum is slowing, building materials industry growth is declining. So the thermal insulation building materials industry depends on the real estate industry is relatively close, growth will be affected. At the same time on the renovation project will involve thermal insulation building materials.

  7.4 、 而且居統計，在歐美國家廣泛用于建筑物的屋頂、墻體、天花板、地板、門窗等作為保溫隔熱材料。歐美等發達國家的建筑保溫材料中約有49%為聚氨酯材料，而在中國這一比例尚不足10%。因此，聚氨酯材料在中國的發展還有很大的空間。

7.4, and the statistics in the European and American countries are widely used in the structure of the roof, walls, ceiling, floor, door to wait as the thermal insulation material. Europe and the United States and other developed countries about 49% of the building thermal insulation material for polyurethane materials, but in China the proportion is less than 10%. Therefore, the development of polyurethane materials in China and a lot of space.

     7.5、中國建筑節能材料的市場較大，尤其是建筑保溫材料市場更大。中國房屋住宅的能量損失大致為墻體約占50%；屋面約占10%；門窗約占25%；地下室和地面約占15%。中國建筑要在2010年實現節能率50%，需對建筑外墻進行全面改造，墻體保溫材料的市場將會大幅度增加。

7.5, China's building energy-saving materials market is bigger, especially construction insulation materials market is bigger. China's housing residential energy loss roughly wall accounted for about 50%; Roof accounts for about 10%; Windows accounts for about 25%; The basement and ground accounts for about 15%. Chinese architecture to realize energy saving rate of 50% in 2010, the need for comprehensive reform, the exterior walls wall thermal insulation material market will increase significantly.